Delphi FE0441 fuel pump and strainer set for the 2004-2008 Ford E-150 V8 4.6L or 5.4L and other vehicles delivers fuel to the engine. As a Delphi fuel pump, it is validated, tested and matched to the right vehicle application.
- Delphi pump built to operate under extreme temperatures with quick engine starts
- Pump design restores fast pressure performance and system integrity with less energy
- Lower amperage draw puts less load on the vehicle's electrical system
- Fuel strainer supplied with the pump, since the strainer is replaced whenever the pump is repaired
Quick facts
- Part: Delphi FE0441 fuel pump and strainer set
- Fits: 2004-2008 Ford E-150 V8 4.6L or 5.4L and other vehicles
- Condition: New
Hard starting, sputtering or lost power can mean a weak pump, but a fuse or relay problem looks much the same. With the key off, look over the fuel pump fuse and relay first, and leave fuel pressure testing to a shop. If the pump is the cause, this set replaces it. Each vehicle takes one set.
Fits
Fitment also includes the 2004-2008 Ford E-250 V8 4.6L or 5.4L and the 2004-2008 Ford E-350 Super Duty V8 5.4L or V10 6.8L. If your vehicle is not named here, run its year and engine through the "Vehicles it fits" section.
Specifications
- Quantity per vehicle: 1
- Type: fuel pump and strainer set
- Condition: New
In the box
One fuel pump and strainer set with a seal, wire harness and connector, isolator, clip, S-shaped hose, metal clamps, zip tie and instruction sheet.
Installation notes
- Check and clean the fuel tank before the new pump goes in.
- Replace the strainer along with the pump; this set supplies both.
- An instruction sheet comes with the set.
Frequently Asked Questions
Does this E-150 fuel pump fit the 2004-2008 Ford E-150 with the V8 4.6L or 5.4L engine?
Yes. Delphi FE0441 fits the 2004-2008 Ford E-150 with either the V8 4.6L or the V8 5.4L, at one set per vehicle.
What comes with this Delphi fuel pump replacement set?
The set has the fuel pump and strainer, a seal, wire harness and connector, isolator, clip, S-shaped hose, metal clamps, a zip tie and an instruction sheet.
Is the strainer included with this Delphi fuel pump assembly?
Yes. Delphi FE0441 is a pump and strainer set, so the strainer is supplied. The strainer should be replaced whenever the fuel pump is repaired.
Does Delphi FE0441 fit the 2004-2008 Ford E-350 Super Duty V10 6.8L?
Yes. Delphi FE0441 fits the 2004-2008 Ford E-350 Super Duty with the V10 6.8L, and also with the V8 5.4L.
What should I do to the fuel tank before installing this pump?
Check and clean the fuel tank before installing the new pump. The set comes with an instruction sheet for the installation.
